replacement of sand by marble powder in concrete
Home > Products > replacement of sand by marble powder in concrete

replacement of sand by marble powder in concrete

What are the Materials for Replacement of Sand in

2 天前 · Instead of disposing them in landfills, it can be best utilized as partial replacement to sand. In crusher dust, the particles (% finer than 150 microns) are generally high, a major concern limiting its percentage replacement to minimum with sand in a concrete

Read More

Study of Properties of Concrete using Marble Powder and ...

2019-7-1 · [1] Nitisha Sharma studied the properties of Waste Marble Powder as a Partial Replacement in Cement Sand Mix This was done by replacing cement by a percentage of marble powder. Four basic concrete mixes were considered. When cement is replaced with marble powder up to 10% weight, high strength concrete was achieved.

Read More

Partial Replacement of Cement With Marble Powder

Marble powder: The marble dust is obtained from RAK ceramics. The specific gravity of tile dust is found to be 2.62 and the fineness is found to be 7.5%. 3.METHODOLOGY: The evaluation of tile powder which is used as a replacement of cement material begins with the concrete

Read More

Partial replacement of sand with marble waste and

In this research work, the effects of using waste marble powder (WMP) as a partial replacement of cement and sand on the properties of the concrete have been investigated. The compressive strength ...

Read More

Partial Replacement of Cement with Marble Dust

2021-2-28 · Experimental Study on Partial replacement of Sand with Marble Dust Powder in high strength concrete Deepankar Kumar Ashish , K. Verma , R. Kumar , Nitisha Sharma , G. Pathan 2018

Read More

Cement Replacement in concrete with Marble Dust Powder

2017-5-20 · of concrete is increased by replacement of cement with marble dust powder up to 10%, and after than adding extra percentage of marble dust powder by replacement of cement, the compressive strength of concrete is start to decrease. According to this study, the replacement of cement up to 10% with marble dust powder in M-20 grade

Read More

Properties of concrete incorporating sand and cement

2016-12-9 · replacement of cement or sand by marble powder for improvement in concrete properties. It shows that sand replacement gives better results as compare to cement replacement. Givi et al. (2010) ... MX1 10% sand replacement with marble powder MX2 10% cement replacement with marble powder

Read More

(PDF) "Partial Replacement of Cement with Marble

Waste Marble Utilization from Residue Marble Industry as a Substitution of Cement and Sand within Concrete Rooftile Production ... 12.3 % . Replacement PC with marble powder by 20 % qualify ...

Read More

THE EFFECTS OF REPLACEMENT OF CEMENT AND SAND

2017-3-14 · powder with cement and sand and checking the physical properties of fresh and hardened concrete. In studying the performance of concrete, a total of eighteen concrete mixes were prepared with replacement of cement and sand with marble powder ranging from 5% to 20% at an increment of 5% by weight.. For each replacement value, two classes of ...

Read More

Project on Partial Replacement of Cement with Marble

QUANTITY OF MARBLE POWDER; 5% of cement replaced by marble powder = 377.38gm 10% of marble powder = 754.7 gm 15% of marble powder = 1.13 kg 20 %of marble powder = 1.5094 kg. Experimental conditions: Compressive strength of concrete was undertaken on 15 cm cubic specimens. at 7 days and 28 days of age.

Read More

(PDF) EFFECT OF QUARRY DUST AS PARTIAL

Design mix of M25grade concrete with replacement of 0%, 20%, 25%, 30%, and 35% of quarry dust organized as M1, M2, M3, M4 and M5 respectively have been considered for laboratory analysis viz ...

Read More

Partial Replacement of Sand with Attapulgite in Concrete

alternative to sand in concrete, Memon et al. [19] have searched in using Marble powder as replacement with five percentages (0, 25, 50, 75, and 100%) by sand

Read More

Project on Partial Replacement of Cement with Marble

In this project our main objective is to study the influence of partial replacement of cement with marble powder , and to compare it with the compressive and tensile strength of ordinary M20 concrete. We are also trying to find the percentage of marble powder replaced in concrete that makes the strength of the concrete maximum.

Read More

Concrete Properties Containing Fine Aggregate Marble

sand with marble powder in concrete because such a mixture will be environmentally friendly and economically feasible. The concrete samples are produced by replacing sand with marble powder

Read More

CIVIL - EXPERIMENTAL PROJECTS - Majestic Project

Compressive Strength of Concrete by Using Lateritic Sand and Quarry Dust CEX042. Use of Industrial Waste Red Mud in the Production of Self Compacting Concrete CEX043. Experimental Investigation of Fibre reinforced Concrete ... Experimental Investigation of Marble Powder as a Partial Replacement

Read More

PARTIAL REPLACEMENT OF CEMENT AND FINE

Use of marble waste powder shows a great performance due to the efficient micro filling ability 4. it, marble powder when replacing with sand up to certain percentage shows almost same strength. 5.

Read More

Investigation on Partial Replacement of Cement with

2020-9-4 · Use of marble dust replacement of cement in the production of concrete for the construction industry should be encouraged where there comparative cost advantage, and improved workability as replacement of marble increase, the compressive strength also increased as with increase of marble powder up to 10% replacement (B. Krishna Rao, 2016).

Read More

Influence of limestone waste as partial replacement ...

This paper reports the experimental study undertaken to investigate the influence of partial replacement of sand with limestone waste (LSW), with marble powder (M.P) as an additive on the concrete properties. The replacement proportion of sand with limestone waste, 25%, 50%, and 75% were practiced in the concrete mixes except in the concrete mix.

Read More

marble powder aggregate - unista.nl

recommended the use of marble powder as a replacement for aggregate, whereas marble powder is used as a replacement for fine sand in conventional concrete (Demirel, 2010). The latter study is in good agreement with Gencel et al. (2012a), who showed that the marble powder improves the overall performance of concrete.

Read More

Marble powder - SlideShare

Objective The objective of the project is to study the behavior of marble dust concrete for water curing. Also we are interested to study the compressive strength of marble dust concrete for 0%, 5%, 10%, 15% & 20%. Replacement of cement by marble dust for water curing.The concrete specimens are then allowed for 7 and 28 days for water curing .

Read More

(PDF) EFFECT OF QUARRY DUST AS PARTIAL

Design mix of M25grade concrete with replacement of 0%, 20%, 25%, 30%, and 35% of quarry dust organized as M1, M2, M3, M4 and M5 respectively have been considered for laboratory analysis viz ...

Read More

THE EFFECTS OF REPLACEMENT OF CEMENT AND SAND

2017-3-14 · powder with cement and sand and checking the physical properties of fresh and hardened concrete. In studying the performance of concrete, a total of eighteen concrete mixes were prepared with replacement of cement and sand with marble powder ranging from 5% to 20% at an increment of 5% by weight.. For each replacement value, two classes of ...

Read More

Ceramic Waste : Effective Replacement Of Cement For ...

2017-2-8 · investigation on strength of concrete and optimum percentage of the partial replacement by replacing cement via 0%, 10%, 20%, 30%, 40% and 50% of ceramic waste. Keeping all this view, the aim of the investigation is to study the behavior of concrete while replacing theceramic waste with different proportions in concrete.

Read More

Influence of Marble Dust as Partial Replacement of

2019-7-1 · replacement, mix was prepared with cement and sand blended with marble dust with replacement from 10%, 20%, 25% and 30%.The investigation indicates that replacement of cement by marble waste powder at different ranges, in concrete production, results in higher compressive strength, split tensile strength and flexural strength as of concrete ...

Read More

PARTIAL REPLACEMENT OF CEMENT AND FINE

Use of marble waste powder shows a great performance due to the efficient micro filling ability 4. it, marble powder when replacing with sand up to certain percentage shows almost same strength. 5.

Read More

Concrete Properties Containing Fine Aggregate Marble

sand with marble powder in concrete because such a mixture will be environmentally friendly and economically feasible. The concrete samples are produced by replacing sand with marble powder

Read More

Mechanical and durability characteristics of marble

2021-3-2 · marble powder as partial replacement in cement con-crete. They used 10% marble powder as replacement for cement and reported that increase in marble powder would signi cantly decrease the workability of concrete. Replacement of cement and sand with marble powder at 10% has been found to improve the mechanical and durability characteristics of ...

Read More

CIVIL - EXPERIMENTAL PROJECTS - Majestic Project

Compressive Strength of Concrete by Using Lateritic Sand and Quarry Dust CEX042. Use of Industrial Waste Red Mud in the Production of Self Compacting Concrete CEX043. Experimental Investigation of Fibre reinforced Concrete ... Experimental Investigation of Marble Powder as a Partial Replacement

Read More

marble powder aggregate - unista.nl

recommended the use of marble powder as a replacement for aggregate, whereas marble powder is used as a replacement for fine sand in conventional concrete (Demirel, 2010). The latter study is in good agreement with Gencel et al. (2012a), who showed that the marble powder improves the overall performance of concrete.

Read More

Light weight concrete with partial sand with wooden

August. 2013 Chandana Sukesh, Katakam Bala Krishna, P.Sri Lakshmi Sai Teja, S.Kanakambara Rao, “Partial Replacement of Sand with Quarry Dust in Concrete” May 2013. Ms.Monica C. Dhoka,“Green Concrete: Using Industrial Waste of Marble Powder, Quarry Dust and Paper Pulp” October 2013 M.V.Rama Raju , K.V.Vivek , Dr. T. Siva Shankar Reddy ...

Read More